Product ID:MAC'S CARB CHOKE & THROTTLE BODY CLEANER
MSDS Date:05/14/1990
FSC:6850
NIIN:00N022719
MSDS Number: BLVWP

VALVOLINE INC

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263

Info Phone: 606-264-7000

Cage: GO029

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 30-35%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ALCOHOL

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 20-25%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

181.70 @ 68F.

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 10-15%

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DIACETONE ALCOHOL; (4-HYDROXY-4-METHYL-2-PENTANONE)

CAS: 123-42-2

RTECS: SA9100000

Fraction By Weight: 1-5%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

SHOULD BE GROUNDED AND/OR BONDED WHEN MATERIAL

RTECS: 9999999ZZ

LUNG DAMAGE, EYE DAMAGE, BRAIN DAMAGE, NERVOUS

RTECS: 9999999ZZ

METABOLIZED TO FORMALDEHYDE & FORMIC ACID.

RTECS: 9999999ZZ

VISUAL DISTURBANCES & BLINDNESS. SINCE METABOLISM IS

RTECS: 9999999ZZ

DELAYED FROM 6-30 HOURS FOLLOWING INGEST. ETHANOL

RTECS: 9999999ZZ

USED AS AN ANTIDOTE. METHANOL IS EFFECTIVELY

RTECS: 9999999ZZ

HAS BEEN COMPLETED. STOP SPILL AT SOURCE, DIKE

RTECS: 9999999ZZ

TANK. REMAINING LIQ MAY BE TAKEN UP ON

RTECS: 9999999ZZ

INTO CONTAINERS.

RTECS: 9999999ZZ

CONDITIONS (SEE YOUR SAFETY EQUIP

RTECS: 9999999ZZ

TO REDUCE EXPOSURE.

RTECS: 9999999ZZ

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 25-30%

OSHA PEL 1000 PPM

ACGIH TLV: SIMPLE ASPHYXIANT

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE SEV IRRIT,
REDNESS, TEARING, BLURRED VISION. SKIN: PRLNGD/RPTD CONT MAY CAUSE
MOD IRRIT, DEFAT, DERM. INHAL: EXCESSIVE INHAL OF VAPS MAY CAUSE
NASAL & RESP IRRIT, CNS EFTS INCLUD ING DIZZ, WEAKNESS, FATIGUE,
NAUS, HDCH& POSS UNCON & EVEN ASPHYXIATION. INGEST: MAY CAUSE GI
(SEE EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IRRIT, NAUS, VOMIT & DIARR. ASPIR OF
MATL INTO LUNGS MAY CAUSE CHEM PNEUMONIA WHICH MAY BE FATAL.
CHRONIC:OVEREXP TO MATL (OR ITS COMPONENTS) HAS BEEN SUGGESTED AS A
CAUSE OF THE FOLLOWING EF TS IN HUMANS: LIVER ABNORMALITIES, EYE
DAM. EFTS IN LAB ANIMALS: LIVER ABNORMALITIES, KIDNEY DAM, ANEMIA,
(SEE ING 7)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN: THORO WASH EXPOSED AREA W/SOAP & WATER. EYE: FLUSH W/LG
AMTS OF WATER FOR AT LEAST 15 MIN LIFTING UPPER & LOWER LIDS
OCCASIONALLY, GET MD ATTN. INGEST:CALL MD/POIS CTL CTR IMMED FOR
INSTRUCTIONS . THIS MATL CONTAINS BOTH METHANOL & PETRO
DISTILLATES. ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM
PNEUMONITIS WHICH CAN BE FATAL. NOTE TO MD: PROD CONTAINS METHANOL.
METHANOL IS (SEE ING 8)

Flash Point Method:TCC
Flash Point:-4F,-20C
Lower Limits:1.2%
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATL IS HIGHLY VOLAT & READILY GIVES OFF
VAPS WHICH MAY TRAVEL ALONG GROUND/BE MOVED BY VENT & IGNITED BY
PILOT LIGHT, OTHER FLAMES, SPKS, HEATERS, (SUPP DATA)

Spill Release Procedures:SM: ABSORB LIQ ON PAPER, VERMICULTIE, FLOOR
ABSORBENT/OTHER ABSORBENT MATL. LG:ELIMINATE ALL IGNIT SOURCES
(FLARES, FLAMES INCLUDING PILOT FLIGHTS, ELEC SPKS). PERS NOT
WEARING PROT EQUIP SHOULD BE EX CLUDED FROM AREA OF SPILL UNTIL
CLEAN-UP (ING 12)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES
(VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS
DATA SHEET MUST BE OBSERVED.

Respiratory Protection:IF WORKPLACE EXPOS LIM OF PROD/ANY COMPONENET IS
EXCEEDED A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA RESPS (NEGATIVE PRESS TYPE) UNDER SPECIFIED (ING 15)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:RESISTANT (NEOPRENE) GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:SMOKING, ELEC MOTORS, STATIC DISCHARGE/OTHER IGNITION SOURCES
AT LOCATIONS DISTANT FROM MATL HANDLING POINT. NEVER USE
WELDING/CUTTING TORCH ON OR NEAR DRUM (EVEN EMPTY) BECAUSE PROD
(EVEN J UST RESIDUE) CAN IGNITE EXPLOSIVELY. ALL 5 GALLON PAILS &
LARGER METAL CNTNRS INCLUDING TANK CARS & TANK TRUCKS (ING 6)

HCC:F2
Boiling Pt:B.P. Text:ING 4
Vapor Pres:ING 4
Vapor Density:HVR/AIR
Spec Gravity:0.84 @ 68F
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR COLORLESS LIQUID.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH: STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME, AND PROLONGED
STORAGE AT ELEVATED TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:SMALL/LARGE SPILLS: DISPOSE OF I/A/W ALL LOCAL,
STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.